Search results

Search the forum Search Articles
  1. Santos_LBZ

    2006 LBZ 4wd Issue

    Well the tone wheeel had an uneven groove all the way around so got a new one, the shift rail had grooves from the mode shift fork worn into causing it to it be smooth, the parts are all the correct ones. I just ordered a new rear case half. the rear snap ring had way too much play so I just...
  2. Santos_LBZ

    2006 LBZ 4wd Issue

    So installed the t-case check all fluids and went for a test drive then. It Kicked made a grinding noise and then I got the codes P0700 and P0735. Not sure what it could be but it limped the tramission and stayed in 4th till I cleared it. Then it did it again but didn't set a code.
  3. Santos_LBZ

    2006 LBZ 4wd Issue

    So got all the part for the rebuild ended up being more than I wanted to spend. But the transfer case got all new bearings and seals, new Planetary Gear, new mode and range fork along with a new hub, new sychro assembly, New shift rail, needed a new tone ring, a new chain, an oil pump, an...
  4. Santos_LBZ

    2006 LBZ 4wd Issue

    Should the front output shaft have been held in by a snap ring? I removed the seal and the front output shaft fell right out should it have been held into the case after the seal was removed or does the seal keep it in place?
  5. Santos_LBZ

    2006 LBZ 4wd Issue

    Yeah I so far I think I know what all needs to be replace looks like I'll be doing the chain, bearings, bushings, oil pump and screen, both forms and the range hub, and if I can get a shop to do the bushing and the other two pressed in bearings
  6. Santos_LBZ

    2006 LBZ 4wd Issue

    How do I know if the bushing in the rear half of the case is good? As well as the main shaft, the input shaft, and the pump
  7. Santos_LBZ

    2006 LBZ 4wd Issue

    So the planetary looks good. Lots of the caked on grease or oil. The synchros will need to be replaced.
  8. Santos_LBZ

    2006 LBZ 4wd Issue

    Ohh okay now how about the chain how do I determine if it needs to be replaced
  9. Santos_LBZ

    2006 LBZ 4wd Issue

    On the filter do I just need to replace the screen piece or the screen and the tube? Also there is two dots on the sprockets. But they weren't lined up to each other is that factor or from someone who opened the case
  10. Santos_LBZ

    2006 LBZ 4wd Issue

    Just ordered a set from the local NAPA gonna pick them up tomorrow morning then I'll get into it more
  11. Santos_LBZ

    2006 LBZ 4wd Issue

    Yeah I considered a rebuilt found one for like 1150. They claim a new chain, bearings, seals, and then what ever was wrong with it I will probably replace the fork as well cuz it's not that expensive. Yeah I figured the synchro most likely is bad haven't opened that part. I'll check the...
  12. Santos_LBZ

    2006 LBZ 4wd Issue

    To me both seem good but I posted them to see what you think let me know what you think
  13. Santos_LBZ

    2006 LBZ 4wd Issue

  14. Santos_LBZ

    2006 LBZ 4wd Issue

    Yeah the fork is toast it had some of the pad on one side the other was just metal to metal. What does that call for? Just replacement or more possible problems?
  15. Santos_LBZ

    2006 LBZ 4wd Issue

    I think a few of the bearings are good but I most likely will just replace them all. The bearing in the output to the front differential is obviously toast and it looks like there is more problems in that area
  16. Santos_LBZ

    2006 LBZ 4wd Issue

  17. Santos_LBZ

    2006 LBZ 4wd Issue

    And the Magnet
  18. Santos_LBZ

    2006 LBZ 4wd Issue

    Here's the pick up and where the magnet goes[/IMG]
  19. Santos_LBZ

    2006 LBZ 4wd Issue

    Yeah I'll upload a picture when I get a chance
  20. Santos_LBZ

    2006 LBZ 4wd Issue

Top Bottom